Product ID:NOX RUST 207
MSDS Date:02/02/1995
FSC:8030
NIIN:00-244-1297
Status Code:A
MSDS Number: CLKTY

DAUBERT CHEMICAL CO

4700 S CENTRAL AVE
CHICAGO, IL 60638-1531
US

Emergency Phone: 800-424-9300

Info Phone: 708-496-7350

Preparer: RYAN MICKELSON

Cage: 7X108

DAUBERT CHEMICAL CO

CHICAGO, IL 60638-1531 US

Telephone: 708-496-7350

Cage: 7X108

ALPHATIC PETORLEUM SOLVENT

CAS: 64742-88-7

PETROLEUM FRACTION

CAS: 67674-14-0

PETROLEUM OIL (SEVERELY SOLVENT REFINED AND/OR SEVERELY

CAS: 64741-96-4

RTECS: PY8040000

PETROLEUM ASPHALT

CAS: 8052-42-4

RTECS: CI9900000

ACGIH TLV: 5 MG/M3

CALCIUM HYDROXIDE

CAS: 1305-62-0

RTECS: EW2800000

OSHA PEL 15 MG/M3

ACGIH TLV: 5 MG/M3

Health Hazards Acute and Chronic:ACUTE EFFECTS: EXCESSIVE INHALATION
MAY PRODUCE DIZZINESS, NAUSEA, HEADACHE, AND INCOORDINATION. MAY
CAUSE SEVERE EYE IRRITATION. PROLONGED SKIN EXPOSURE MAY CAUSE
DERMATITIS OR OIL ACNE. BREATHING MI STS MAY CAUSE DIZZINESS OR
PULMONARY IRRITATION. CHRONIC EFFECTS: SOME ASPHALT SOLUTIONS HAVE
PRODUCED SKIN CANCER IN LABORATORY ANIMALS. THE ACTIVITY OF TEST
MATERIALS VARIES WIDELY, BUT THE ACTIVIT Y IN GENERAL, IS WEAK.
BASED ON THE SKIN PAINTING DATA, IARC HAS CONCLUDED THAT THERE IS
SUFFICIENT EVIDENCE FOR CARCINOGENICITY OF ASPHALTS, DILUTED,
DISSOLVED, OR LIQUIFIED IN SOLVENTS, IN LABORATOR Y ANIMALS.
WORKERS, THEREFORE, WHO PRACT
Explanation of Carcinogenicity:ASPHALT SOLUTIONS ARE CONSIDERED TO BE
ANIMAL CARCINOGENS BY IARC.
Effects of Overexposure:CHRONIC OVEREXPOSURE: PROLONGED OR REPEATED
EXPOSURE FROM POOR HYGIENE, HOUSEKEEPING OR HANDLING PRACTICES
COULD CAUSE LEAD POISONING. EARLY SYMPTOMS ARE FATIGUE, DISTURBANCE
OF SLEEP, AND CONSTIPATIO N, WITH MORE SEVERE EXPOSURES FOLLOWED BY
COLIC, ANEMIA AND NEUITIS. PROLONGED OVEREXPOSURE CAN SEVERLY
DAMAGE RED BLOOD CELL FORMATION, KIDNEYS, AND NERVOUS SYSTEM. OTHER
SYPTOMS INCLUDE LOSS OF APET ITE, METALLIC TASTE IN MOUTH, ANXIETY,
NAUSEA, PALLOR, HEADACHE, DIZZINESS AND HYPERTENSION. THE OSHA LEAD
STANDARD REPORTS THAT LEAD MAY IMPAIR THE REPRODUCTIVE SYSTEM OF
BOTH MEN AND WOMEN, DAMAGE M AY ALSO BE CAUSED TO THE UNBORN FETUS.
Medical Cond Aggravated by Exposure:EXPOSURE MAY AGGRAVATE PRE-EXISTING
RESPIRATORY OR SKIN PROBLEMS.

First Aid:INHALATION: MOVE VICTIM TO FRESH AIR AND CALL EMERGENCY
MEDICAL CARE. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION, IF
BREATHING IS DIFFICULT, GIVE OXYGEN. EYES: IN CASE OF CONTACT
WITH MATERIAL, I MMEDIATELY FLUSH EYES WITH RUNNING WATER FOR AT
LEAST 15 MINUTES. SEEK IMMEDIATE MEDICAL ATTENTION. SKIN: WASH
SKIN WITH SOAP AND WATER. REMOVE AND ISOLATE CONTAMINATED CLOTHING
AND SHOES AT THE SITE . INGESTION: DO NOT INDUCE VOMITING, CONSULT
A PHYSICIAN. IF VOMITING OCCURS SPONTANEOUSLY, KEEP HEAD BELOW HIPS
TO PREVENT ASPIRATION OF LIQUID INTO THE LUNGS.

Flash Point Method:TCC
Flash Point:=40.6C, 105.F
Lower Limits:0.6
Upper Limits:7.0
Extinguishing Media:SMALL FIRES: DRY CHEMICAL, CO2, WATER SPRAY, OR
REGULAR FOAM. LARGE FIRES: WATER SPRAY, FOG, OR REGULAR FOAM. MOVE
CONTAINER FROM FIRE AREA IF YOU CAN DO IT WITHOUT RISK. APPLY COOLI
Fire Fighting Procedures:FIRE MAY PRODUCE IRRITATING OR POISONOUS
GASES. POSITIVE PRESSURE SELF-CONTAINED BREATHING APPARATUS AND
STRUCTURAL FIREFIGHTERS PROTECTIVE CLOTHING WILL PROVIDE LIMITED
PROTECTION. KEEP UNNECESSARY P EOPLE AWAY; ISOLATE HAZARD AREA AND
DENY ENTRY. STAY UPWIND; KEEP OUT OF LOW AREAS. ISOLATE FOR 1/2
MILE IN ALL DIRECTIO
Unusual Fire/Explosion Hazard:FLAMMABLE/COMBUSTIBLE MATERIAL; MAY BE
IGNITED BY HEAT, SPARKS OR FLAMES. VAPORS MAY TRAVEL TO A SOURCE OF
IGNITION AND FLASH BACK. CONTAINER MAY EXPLODE IN HEAT OF FIRE.
VAPOR EXPLOSION HAZARD INDOOR S, OUTDOORS OR IN SEWERS. RUNOFF TO
SEWER MAY CREATE FIRE OR EXPLOSION HAZARD.

Spill Release Procedures:SHUT OFF IGNITION SOURCES; NO FLARES, SMOKING
OR FLAMES IN HAZARD AREA. STOP LEAK IF YOU CAN DO IT WITHOUT RISK.
SMALL SPILLS: TAKE UP WITH SAND OR OTHER NONCOMBUSTIBLE ABSORBENT
MATERIAL AND PLACE IN TO CONTAINERS FOR LATER DISPOSAL. LARGE
SPILLS: DIKE FAR AHEAD OF LIQUID FOR LATER DISPOSAL.

Handling and Storage Precautions:STORE IN A COOL, WELL VENTILATED AREA.
KEEP AWAY FROM FLAMES, SPARKS OR HOT SURFACES. NEVER USE A TORCH TO
CUT OR WELD ON OR NEAR CONTAINER. EMPTY CONTAINERS CAN CONTAIN
EXPLOSIVE VAPORS.
Other Precautions:NEVER WEAR CONTAMINATED CLOTHING. LAUNDER OR DRY
CLEAN BEFORE WEARING. DISCARD OIL-SOAKED SHOES. WASH THOROUGHLY
WITH SOAP AND WATER AFTER USE AND BEFORE SMOKING OR EATING. AVOID
EXCESSIVE SKIN CONTAC T.

Respiratory Protection:NIOSH-APPROVED RESPIRATOR FOR ORGANIC VAPOR AND
MIST TO CONTROL EXPOSURE WHERE VENTILATION IS INADEQUATE.
Ventilation:GENERAL AND LOCAL EXHAUST
Protective Gloves:IMPERVIOUS GLOVES
Eye Protection:SAFETY GLASSES WITH SIDESHIELDS OR CHEMICAL GOGGLES
Other Protective Equipment:IF SPLASHING IS ANTICIPATED, WEAR RUBBER
APRON AND BOOTS OR OTHER PROTECTIVE EQUIPMENT TO MINIMIZE CONTACT.
Supplemental Safety and Health

Boiling Pt:>148.9C, 300.F
Vapor Pres:3.4
Vapor Density:>1
Spec Gravity:0.896
Evaporation Rate & Reference:<1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK LIQUID, PETROLEUM SOLVENT
Percent Volatiles by Volume:36

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, OXIDIZING AGENTS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF SULFUR, MISCELLANEOUS HYDROCARBONS.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH STATE, LOCAL AND
FEDERAL REGULATIONS. MATERIALS MAY BECOME A HAZARDOUS WASTE THROUGH
USE. IF PERMITTED, INCINERATION MAY BE PRACTICED. CONSIDER
RECYCLING SOLVENT.

SARA Title III Information:THIS PRODUCT CONTAINS THE FOLLOWING TOXIC
CHEMICALS SUBJECT TO THE REPORTING REQUIREMENTS OF SEC. 313 OF
TITLE III OF THE SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT O
1986, AND OF 40 CFR PART 372. L EAD SOAP OF OXIDIZED PETROLEUM
FRACTION 67674-14-0 ALSO HAZARDOUS SUBSTANCES ALIPHATIC PETROLEUM
SOLVENT 64742-88-7, 64742-47-8, 8052-41-3
State Regulatory Information:CALIFORNIA PROPOSITION 65: THIS PRODUCT
MAY CONTAIN TRACE QUANTITIES OF THE FOLLOWING CHEMICALS THAT ARE
IDENTIFIED BY THE STATE OF CALIFORNIA UNDER THE SAFE DRINKING WATER
AND TOXIC REINFORCEMENT ACT OF 1986 AS EITHER A CARCINOGENIC OR
REPRODUCTIVE HAZARD: 8052-42-4, AND 67674-14-0.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.